install new fuel pump > how much work
#1
Burning Brakes
Thread Starter
Member Since: Apr 2009
Location: Kopavogur in Iceland
Posts: 762
Likes: 0
Received 2 Likes
on
2 Posts
install new fuel pump > how much work
hi
How much work is it to install new ractronix fuel pump in tank, replace the old one, and install the new racetronix wire harness...
in 2003+ fuel system version C5
is it rear cradle/suspension and tranny out or?
thanks
Baezi
How much work is it to install new ractronix fuel pump in tank, replace the old one, and install the new racetronix wire harness...
in 2003+ fuel system version C5
is it rear cradle/suspension and tranny out or?
thanks
Baezi
#5
Burning Brakes
If your fuel pump is on top of the left tank, then you have the FFS fuel system. The driveline has to be removed to be able to remove the fuel tank. What is your fuel pressure dropping to at WOT at redline? Maybe a boost a pump will increase the output enough.
Russ Kemp
This article says you don't have to remove the driveline; http://www.corvetteactioncenter.com/...el+Tank+System
Russ Kemp
This article says you don't have to remove the driveline; http://www.corvetteactioncenter.com/...el+Tank+System
Last edited by Russ K; 09-14-2010 at 05:35 PM.
#6
Burning Brakes
Thread Starter
Member Since: Apr 2009
Location: Kopavogur in Iceland
Posts: 762
Likes: 0
Received 2 Likes
on
2 Posts
If your fuel pump is on top of the left tank, then you have the FFS fuel system. The driveline has to be removed to be able to remove the fuel tank. What is your fuel pressure dropping to at WOT at redline? Maybe a boost a pump will increase the output enough.
Russ Kemp
This article says you don't have to remove the driveline; http://www.corvetteactioncenter.com/...el+Tank+System
Russ Kemp
This article says you don't have to remove the driveline; http://www.corvetteactioncenter.com/...el+Tank+System
i was hoping to see pics from somebody of step by step installing a fuel pump in 2003-2004 Vette
baezi
#8
Burning Brakes
Thread Starter
Member Since: Apr 2009
Location: Kopavogur in Iceland
Posts: 762
Likes: 0
Received 2 Likes
on
2 Posts
Just finished my Racetronix pump harness install.
1.The Drive train went down
2. left tank needs to go down: needs to disconnect lines between the tanks (it´s disconnected on the left tank)
3. Disconnect hose on top of the left tank (the refill hose) and disconnect air hose there too
4. Disconnect fuel line and a plug
the tank is loose
5. Then it´s opening the tank up
6. taking the pump and acessories up out of the tank is very tight and stiff, but whith pation it´s will come up
7. then swapping pumps, plug n´d play, and clean it all well
8. Install again
it´s not a hard work, but offcousre this all takes time, if it´s the first time.
Baezi
1.The Drive train went down
2. left tank needs to go down: needs to disconnect lines between the tanks (it´s disconnected on the left tank)
3. Disconnect hose on top of the left tank (the refill hose) and disconnect air hose there too
4. Disconnect fuel line and a plug
the tank is loose
5. Then it´s opening the tank up
6. taking the pump and acessories up out of the tank is very tight and stiff, but whith pation it´s will come up
7. then swapping pumps, plug n´d play, and clean it all well
8. Install again
it´s not a hard work, but offcousre this all takes time, if it´s the first time.
Baezi