Theta

The following How-To Guides cover numerous topics and offer pictures, explanations, specifications, schematics, etc of how to work on your C7 Corvette Stingray.

These How-To Guides are neither endorsed by nor property of Corvette Forum or myself in any way/shape/form. All liability stemming from any actions taken in relation to these guides is solely placed upon the user.

Please continue to check back often, as this thread will continue to grow as more How-To Guides are added!

We hope you will find these guides useful.

Updated (2/28/15) - Major Overhaul, Added Sections/Dividers, Added Member How-To Guides Section

Updated (4/8/15) - Added Additional Member How-Tos

Updated (4/29/15) - Added Front/Rear Brake Rotor How-Tos

Updated (7/21/15) - Added Additional User-Submitted How-Tos / Cleaned-Up Some Older How-To Entries

Updated (8/26/15) - Added Additional User-Submitted How-Tos
_______________________________________

Specifications: Engine (6.2L LT1) Fastener Tightening / Torque Values

Specifications: Transmission (7-Speed Manual) Fastener Tightening / Torque Values

Specifications: Clutch (7-Speed Manual) Fastener Tightening / Torque Values

Specifications: Suspension (Front & Rear) Fastener Tightening / Torque Values

Specifications: Frame & Underbody Fastener Tightening / Torque Values

How-To: Lift/Jack The Vehicle Per GM Specifications

How-To: Bleed Brake System / Change Brake Fluid (Manual & Pressure) + Specs

How-To: Remove/Replace Front Brake Pads

How-To: Remove/Replace Rear Brake Pads

How-To: Remove/Replace Front Brake Calipers

How-To: Remove/Replace Rear Brake Calipers

How-To: Remove/Replace Front Brake Rotors

How-To: Remove/Replace Rear Brake Rotors

How-To: Replace Parking Brake Shoe, Electronic Emergency Brake Module + Schematics

How-To: Remove/Replace Exhaust Manifolds, Cats, X-Pipe / Prep for Header Install

How-To: Perform/Check Front/Rear Wheel Alignment

How-To: Remove/Replace Front Shock Absorbers

How-To: Remove/Replace Rear Shock Absorbers (with FE2,FE4)

How-To: Remove/Replace Rear Shock Absorbers (without FE2,FE4)

How-To: Remove/Replace Front Leaf Spring

How-To: Remove/Replace Rear Leaf Spring

How-To: Remove/Replace/Install Front Sway Bar

How-To: Remove/Replace/Install Rear Sway Bar

How-To: Bleed/Fill Rear Differential and Hydraulic System Service + Specs

How-To: Bleed Hydraulic Clutch System + Specs

How-To: Install Short Shifter / Replace Stock Shifter

How-To: Connect/Disconnect the Negative Battery Cable

How-To: Remove/Replace Vehicle Battery

How-To: Replace Front Headlamp HID Bulb

How-To: Adjust / Aim HID Headlamps

How-To: Drain/Fill Engine Oil & Replace Oil Filter (Dry Sump) + Specs

How-To: Drain/Fill Engine Oil & Replace Oil Filter (Wet Sump) + Specs

How-To: Drain/Fill Manual Transmission (All Models) + Specs

How-To: Remove/Replace Door Sill Trim Plate(s)

How-To: Remove/Replace the Instrument Panel Trim Pad (Passenger Dash)

How-To: Remove/Replace Left (Driver) Door Interior Trim Panel

How-To: Remove/Replace Right (Passenger) Door Interior Trim Panel

How-To: Remove/Replace Steering Wheel

How-To: Remove/Replace Rear Quarter Panel (Fender) - Driver's Side

How-To: Remove/Replace Rear Quarter Panel (Fender) - Passenger's Side

How-To: Remove/Replace Rear Quarter Panel Air Scoops

How-To: Remove/Replace Front Bumper Fascia

How-To: Remove/Replace Lower Rear Bumper Fascia

How-To: Remove/Replace Upper Rear Bumper Fascia

How-To: Remove/Replace the Outside Rearview Mirror

How-To: Remove/Replace the Outside Rearview Mirror Glass

How-To: Remove/Replace the Outside Rearview Mirror Inner Actuator

How-To: Remove/Replace Front/Side/Rear Emblems & Nameplate

How-To: Remove/Replace Front Wheelhouse Liner

How-To: Remove/Replace the Intake Manifold Covers

How-To: Remove/Replace Valve Rocker Arms & Pushrods

How-To: Remove/Inspect/Install the Cylinder Heads

How-To: Remove/Clean/Replace the Fuel Rail & Injectors

How-To: Remove/Replace Intake Manifold

How-To: Remove/Replace Spark Plugs / Plug Wires

How-To: Remove/Replace Front Center Speaker

How-To: Remove/Replace LEFT Upper Dash Tweeter

How-To: Remove/Replace RIGHT Upper Dash Tweeter

How-To: Remove/Replace Left (Driver) Upper and Lower Door Speakers

How-To: Remove/Replace Right (Passenger) Upper and Lower Door Speakers

How-To: Remove/Replace LEFT Rear Speakers

How-To: Remove/Replace RIGHT Rear Speakers

How-To: Remove/Replace Rear Subwoofer Assembly

How-To: Remove/Replace Speaker Amplifier

How-To: Identify Wiring To/From Audio Amplifier

NEW: Member-Written How-To Guides:

These guides have been selected from the countless threads here for being verified, helpful, and informative. All disclaimers above apply, and please note that these guides are neither monitored nor updated officially or unofficially by any staff or technical writers - they are the sole property and responsibility of the original author. If said author wishes to be removed from this list, please contact me via PM.

How-To: Add / Relocate Additional Windshield Washer Reservoir & Pump on Non-Z51 (Helpful for Meth)

How-To: Install Alky Control Meth Injection System for C7

How-To: Install/Upgrade to Z51 Brake System from Base C7

How-To: Install/Upgrade to Z51 Brake Ducts from Base C7

DIY: Painting Engine Bay Parts

How-To: Lower The Vehicle on Stock Bolts

How-To: Install Flex Fuel Sensor

How-To: Convert GT Seats to Competition Seats

How-To: Convert/Swap Upper Interior Panels to Sueded Microfiber

How-To: Remove Rear Fascia (with Pictures)

How-To: Remove Front Fascia / Front Bumper Cover (with Video & Pictures)

How-To: Self-Calibrate Stubborn TPMS Sensors

DIY: manual transmission and rear differential fluid service

[Mod] Switched AUX power jacks - making them always hot

pewter99

Thank you for all your time and effort in creating the threads and taking the time to consolidate them in one thread.

$$$frumnuttin'

Thanks for doing this Theta and Pewter99....the timing is great as we are seeing lots of folks digging into their cars with some fine mods.

Jerry

Road_runner

Nice job
Could we ge a How-to on Harness Bars?

Theta

At the moment, we don't have any specific installation information from any of the current vendors on their bar installation processes.

Once we do, and/or there are more bars on the market, I will be happy to add this information for you along with panel dis-assembly instructions.

pbrayton

i know i saw a video of this but can't find it now even with search. does anyone have it?

1jester

how do you check the dic codes on a c7?

Theta

Are you referring to P-Codes?

Theta

Added to the list. Here: http://forums.corvetteforum.com/c7-g...nd-photos.html

jspridge

Thanks for posting this information. Would you be able to add procedures for replacing the speakers in the doors and other interior panels?

Theta

Absolutely - this is on my list, but I will bump it to the top for you. Expect the post later on today.

jspridge

Thanks very much!

Theta

All of the audio system is now posted... phew - that took a while!

millers1

Any info on how hard it is or what's involved in changing the plenum cover?

Theta

It's not hard at all. The thermal pad on top of the intake manifold does require the intake manifold to come out, though (if you don't want to damage it).

I will put up a guide on the manifold removal and perhaps the throttle body since those are becoming more popular.

Keep an eye out for the intake manifold guide, as it will have the prerequisites of plenum removal.

drewauby5

how about a DIY for brake caliper removal and reapplication with parts necessary to perform. I am going to have my calipers powdercoated and had done the same on my C6 and there was a great step by step with pictures posted in the C6 section. Thanks in advance, Andrew

Asterism

Theta

I'll make a note to do this tomorrow - been way behind on a lot of things.

drewauby5

any help on caliper removal and reinstall instructions??? THanks

Theta

Also working on this now. ETA is around an hour for both of these requests.