CorvettePartsBob

Hello! This is Bob, thanks for taking the time to read my weekly newsletter with information and special parts pricing for Corvette Forum members. Be sure to check the important announcements section!

REMEMBER WE OFFER ANY GM PART AT GM WHOLESALE PRICES FOR ANY GM VEHICLE!!!


OUR HOURS ARE 7:30 TO 5:30 MOUNTAIN TIME MONDAY THRU FRIDAY
8:00 TO 12:00 MOUNTAIN TIME SATURDAY
OUR PARTS HOTLINE IS 406-628-4121 or 406-628-4618
Bob is extension 108 and Tom is extension 107
FAX # 406-628-2025
EMAIL:
Parts: parts@fichtnerchevrolet.com

NEW: DIRECT ORDER SITE FOR PARTS SPECIALS
GO HERE FOR POPULAR PARTS SPECIALS THESE
PRICES ARE GOOD THRU 01/30/04 http://www.corvetteforum.net/c5/kenf...rtspage1.shtml



INDEX

A: Important Announcements
B: New Products
C: Technical Service Bulletins and Recalls and Technical Information
D: Specialty Parts and Parts Information
E: Shipping and handling and warranty information


A: IMPORTANT ANNOUNCEMENTS

New email addresses!!
Parts: parts@fichtnerchevrolet.com

This site is completely secure, no need to worry about credit card #

CHECK OUT OUR SEPARATE WEEKLY PARTS SPECIAL ON A SEPARATE POST ON THE FORUM!

WE NOW HAVE A SPECIAL C4 SECTION

GM CORVETTE ACCESSORIES WEB SITE
http://www.gmgoodwrench.com/accessor...94978921770590

HUMMER H2 PARTS NOW AVAILABLE ATWHOLESALE PRICES

WATCH FOR OUR WEEKLY SPECIALS ON SEPARATE POSTS ON THE FORUM
Due to the response to our specials on our web order site we will continue them !

CORSA INDY PACE WITH CLASSIC TIPS
WHILE THE SUPPLY LASTS WE HAVE THEM AT $779.00 PLUS SHIPPING. THESE LIST FOR $1039.00 IF ORDERING DIRECT FROM CORSA!


AT this time GM is not going to offer the F55 Magnaride system as an upgrade conversion kit. It is supposedly still in the discussion stages, but is on indefinite hold at this time by GM. Delphi is ready to go with the kit, the hold up is GM.

The 2004 GM Performance Parts Catalogue will be coming out in February. If GM doesn’t change the price they will be $5.95 ea. Get your order in now to be the first to get one.


WE NOW OFFER GIFT CARDS! THESE ARE AVAILABLE IN ANY DOLLAR INCREMENT UP TO $999 THESE ARE PURCHASEABLE WITH CHECK OR CASH. DUE TO THE PROGRAM RESTRICTIONS THEY CAN’T BE PURCHASED WITH A CREDIT CARD. IF YOU HAVE SOMEONE THAT IS HARD TO BUY FOR, BUT YOU KNOW THEY ALWAYS ARE AFTER PARTS FOR THEIR VEHICLES THIS IS AN OPTION. FOR FURTHER INFORMATION CALL BOB, TOM OR KEN AT 406-628-4618

UPF 44 FILTERS ARE STILL AVAILABLE FOR 7.95 EA IN QUANTITIES OF 6 OR MORE! REGULAR PRICE IS 8.95 EA.

B: NEW PRODUCTS

PROMO MODEL SPECIALS

2003 CORVETTE PACE CAR COUPE (PACED THE 2002 RACE)
moulded in Anniversary Red with all of the 86th Annual Indy Pace Car Decals!
Sale Priced at $39.00 plus 6.99 s&h

2001 Convertible-discounted to $29.00 with free shipping
white exterior with red interior

2001 Z06 Hardtop-discounted to $29.00 with free shipping
millennium yellow with black interior

1963 Corvette Split Window Coupe Combo- discounted to $50.00 with free shipping
In commemoration of this unique car Chevrolet authorized the release of a special promo
package that includes: two 1:25 scale plastic promotional models pre-colored in Bronze and Black with highly detailed chassis and interiors.

2003 50th Anniversary Two Car Package
one coupe and one convertible in anniversary colors.
$69.95 plus 6.99 s&h
very limited quantity……

1963 Corvette Convertible and Split Window Coupe Combo
This is a new kit, the convertible is light blue with dark blue interior. The coupe is dark blue with oak interior. This is a limited edition collectors set certified by GM. We have them on special at 69.00 with free shipping.


50TH ANNIVERSARY INDY PACE CAR DECAL PACKAGE
This is a 19 piece graphics package, instructions, and applicator squeegee. Again this will be a limited availability. Retail is $495.00 plus s&h. Your cost is $465.00 plus s&h.

50th ANNIVERSARY ITEMS
GM says prices are temporary and may change at any time, also parts availability is very tight. As of now we have the following items available:

Shale floor mats…embroidered with 50th logo….94.00 a set
All metal stick on 50th anniversary fender emblems…..57.83 ea.
Rear decklid/hatch stick on 50th anniversary emblem…31.56 ea
Front end stick on 50th anniversary emblem…32.78 ea
QD4 Option Wheels front 17x8.5 381.75 ea
QD4 Option Wheels rear 18x9.5 442.98 ea
Center Caps 22.85 ea
Upper Dash Pad 600.51
Glove Box Door Assy 159.05
Knee Bolsters LH 66.37
Knee Bolster Panel 29.36
Door Panels LH & RH 454.73 ea
Sill Mldgs LH & RH 25.36 ea
Center Console & Radio Bezel 93.09
Center Console Lid 140.26
Center Console Housing 148.66
Center Bezel with Air Bag Light 32.46
Seat Covers Seat Back Covers 107.07 ea
Seat Back Inserts 102.15 ea
Bottom Cushion Covers 186.54 ea

NOTE: GM SAYS MANY OF THESE PRICES ARE TEMPORARY AND SUBJECT TO CHANGE…give us a call at 406-628-4121 for latest pricing

IT’S OFFICIAL!!
RM Racing’s C5 Twin Flow Air Intake is now an Officially Licensed GM Product
Independently dyno tested with peak gains up to 10+ hp at the rear wheels
3.5” mandrel bent, merged air tubes constructed of aluminized steel
Black wrinkle powder coated to resist corrosion and to match the C5’s other engine components
T-304 stainless steel coupler
Installation time is 25 minutes with no modifications required
RETAIL $395.00 FORUM COST $355.00

CORSA EXHAUST
We offer the famous Corsa Exhaust systems for C5 and C4 Corvettes!
Corsa also offers systems for the new Silverado/Sierra Pickups Tahoe/Suburbans/Yukon/Escalade and the Avalanche

Call us at 406-628-4121 or email at corvetteparts@hotmail.com for the current special pricing. WE CAN MATCH OR BEAT MOST PRICES!
2003 GM PERFORMANCE PARTS CATALOGUE NOW AVAILABLE $5.95
THE SAME CATALOGUE IS ALSO AVAILABLE ON CD..special order $8.95

NEW STYLE STAINLESS STEEL CAPED LUG NUTS
The stainless steel caped lug nuts that the assembly line is converting to are available.
There is also a locking lug nut set available

NEW CORVETTE ACCESSORIES FROM GM
If prices are not posted please call us for the current pricing and availability at 406-628-4618 or email at corvetteparts@hotmail.com
Front-end cover (bra) GM Corvette Logo (except Z06) $74.80 ea
Front-end cover (bra) GM Z06 Logo (Z06 option) $74.80 ea

Multiple Car Covers..Fast Top to Premium Covers..prices from $75.00 to $250.00
Oversize Carpeted Floor Mats..multiple colors and embroidered.. call or email for prices.
Rubber under car mat with C5 logo, available in multiple colors
Black carpeted trunk mat with embroidered C5 logo in multiple car colors
Black carpeted deck lid liner with embroidered C5 or Z06 logo in multiple car colors
Vette Net Wind Break
Custom Corvette Logo sill plates avail. In black gold, chrome and black chrome
Clear sill protectors with white or black lettering
Interior dash kits available in brushed aluminum, carbon fiber, burlwood or millennium yellow.
Corvette Logo license plate frames, polished bright, black powder coat, black pearl coat, and carbon fiber.
Corvette Logo valve stem caps available in black w/silver or silver w/black
Multiple styles of shift ***** including Billet
Neoprene slip seat covers, black with colored inserts and C5 or Z06 logo
Polyester-cotton slip seat covers in multiple colors
Corvette Logo Center Arm Rest Covers
Cast Aluminum gas and brake pedals
Silver Windshield Shades with choice of C3, C4 or C5 logo

Underhood Carbon Fiber Covers
Polished brass and chrome plated intake manifold and fuel rail covers
Underhood blankets with painted logo.
Billet aluminum exhaust plates
C05 and Z06 logo tail lamp and third brake lamp covers


C: TECHNICAL BULLETINS..RECALLS..INFORMATION

GM OIL LIFE SYSTEM...HOW DOES IT REALLY WORK
This is taken from the May 2003 GM Techlink publication
How often should engine oil be changed? 3,000 miles, 5,000 miles, 7,500 miles, 10,000 miles? Actually, all of these are correct, depending on operating conditions. Oil life is affected by many factors other than just miles driven. The type of driving, temperature, and engine load all play a part.
That’s why GM has developed the GM Oil Life System, an electronic watchdog that keeps track of all these variables and notifies the driver when it’s time to change oil. This system has become standard equipment on nearly all GM products since 2000.
Briefly, the Oil Life System is programmed with a certain number of engine revolutions. As the engine runs, this number is reduced until it reaches zero, and the Oil Life light or message comes on. But there’s more. Operating the engine under low or high temperatures, and under high load conditions subtracts (penalizes) extra revolutions, so the light comes on sooner. Changing engine oil according to actual need rather than an inflexible schedule provides several benefits.
First is simplified determination about when to change oil. No more decisions about normal conditions vs. severe conditions. Second is reduced operating costs for GM’s customers, who now have to change oil only when it’s needed. Third is minimizing the amount of used oil that must be disposed of. And fourth, engines will always be running with sufficiently fresh oil, for long life.
Traditionally, the vehicle maintenance schedule has been based on miles or time, while the oil change interval is now based on the GM Oil Life System.
When the change engine oil light or message comes on, it means that service is required on the vehicle. I should be serviced as soon as possible within the next 600 miles. It is possible that, under the best conditions, the engine oil life system may not indicate that vehicle service is necessary for over a year. However, engine oil and filter must be changed at least once per year, and at this time the system must be reset.

HOW DO I RESET?

The oil reset information is in your owners manual. This is how to reset the 2001-2004 corvette.
Turn the ignition to ON, with the engine off.
Press the trip button so the OIL LIFE percentage is displayed.
Press RESET and hold for two seconds. OIL LIFE REMAIN 100% will appear.

2003 Convertibles and Z06 ..rear decklid not flush or only one strut on hinge.

Technical Service Bulletin 03-08-66-001 dated 01/13/03
This bulletin calls for replacing the RH deck lid hinge and installing two rear struts. This is not a recall, but a bulletin telling the dealer how to do the repair for this complaint, and is covered while the car is under warranty.

AUDIBLE SPARK KNOCK (DETONATION) MIL ILLUMINATED

Technical Service Bulletin 02-06-04-023 dated 05/01/02
If you have DTC P0332 set ( replace rear bank knock sensor and rtv area around sensor) This applies to 1998-2002 Camaro, Corvette, and Firebird with 5.7L engine (vin G – RPO LS1)

DOOR GLASS RATTLE

Technical Service Bulletin 83-15-05 dated 04/24/1998
This bulletin refers to door glass rattles in the full down position when closing the door. This rattle is probably the result of the glass rattling against the regulator pulley and cable guide.
Remove the trim pad, clean cable guide and roller with general purpose cleaner. Install a piece of hook and loop material (loop side) to the center of the roller and also to the front or rear green color cable guide. Reinstall the trim pad.

SPECIAL CONSIDERATIONS FOR AGM BATTERIES

This is a quote from the August 2002 Tech Link Publication
The Absorbent Glass Mat (AGM) battery uses absorbent glass mats to hold a small amount of electrolyte in contact with the plates. The battery uses gas recombinant technology, which means the gases produced at the plates are recombined to form water before they escape. This battery design offers higher power for lower weight, and is more resistant to high temperatures, vibration and cycling, making it ideal for the Chevrolet Corvette.
The AGM battery may be charged using the new automatic charges. However, when using a conventional charger, limit the rate to 10 amperes or less. Do not allow the battery to charge at 3 amperes or more for longer than 10 hours, or 10 amperes or more for longer than 5 hours. When these limits are reached, allow the battery to stand overnight, then resume charging, if further charging is required.
Check the voltage every 30 minutes and remove the battery from charge when the voltage reaches 15 volts at 3-10 amperes. The state of charge is now at 90 to 95%.

HYDRAULIC CLUTCH FLUID DISCOLORATION


This is a quote from the August 2002 Tech Link Publication the hydraulic clutch system of 1997-2002 Chevrolet Corvettes may appear discolored. This discoloration is the result of carbon black used in the seal manufacturing process leaching out into the hydraulic fluid used in the clutch system.
The discoloration may also collect on the inside of the clutch reservoir at the top of the fluid. This discoloration does not affect the operation of the clutch system and should not be considered a reason to flush the clutch hydraulic system.

WHISTLE NOISE FROM INTAKE MANIFOLD/THROTTLE BODY

This is a technical service bulletin for repair of this problem, it is not a recall. It covers 2001 Corvettes LS1, LS6 engines. TSB # 02-06-01-021
Some owners may comment on a whistle noise coming from either the intake manifold or the throttle body. The noise is most noticeable between 1100 and 2000 RPM.
This bulletin calls for replacing the intake manifold.

DRIVER SEAT MOVEMENT DURING ACCELERATION AND BRAKING

This is a technical service bulletin out to repair this problem, it is not a recall. It covers 1997-2002 corvettes with power seats prior to vin 25106379. TSB # 02-08-50-002
This bulletin calls for replacing both seat adjusters.

CONVERTIBLE TOP PAINT WEAR THROUGH AT FIFTH BOW

There is a new service bulletin out for this paint wear problem on 1998-2001 C5 convertibles. TSB # 02-08-111-001
This is for cars that have paint around the tonneau cover at the 5th bow wearing through.
The correction is to replace the 5th bow seal.
THIS IS NOT A RECALL…but a how to repair the problem for service departments. If your car is still under warranty, I would call this to your dealers attention. If you are out of warranty and want the repair, contact me at corvetteparts@hotmail.com or call me at
406-628-4618 and I can get you the repair info and part.

WATER LEAK PROBLEMS-REPAIRS

GM has released a new 9 page service bulletin dealing with probable causes and the repair for multiple waterleak areas on the C5. TSB #02-08-57-003 dated May 2002. If you are having a problem with yours and is under warranty contact your dealer and have them refer to this bulletin. If you are out of warranty give me a call at 406-628-4618 and I can go over your individual problem with you. This is too detailed to handle in an email.

STEERING COLUMN LOCK UP

Steering column may refuse to operate, DIC service message displayed. TSB # 01-02-35-008 refers to update column lock wiring, install revised relay and/or replace electronic column lock. This was a problem on all 1997 and certain 1998-2000 C5’s. Depending on the year and if manual or automatic trans.; parts cost range from wholesale price of 95.00 to 130.00. If you have this problem and the car is still under warranty take it to your dealer and have them refer to this bulletin. If not I can provide you the parts. Warranty labor time is about 1 hour to repair.

PREMATURE WEAR OF LEATHER MATERIAL ON BUCKET SEATBACK BOLSTER

1997-1999 Corvette built prior to vin breakpoint X5116322
This is a repair under warranty only, and calls for replacement of the seat cover assembly.

Tire Pressure Monitoring System Update

This is from a GM Tech Link Bulletin
Components: There is a separate sensor/transmitter in each wheel. The TPM (tire pressure monitor) system shares the receiver with the keyless entry system. Data from the receiver is displayed on the instrument panel, using the driver information center (DIC).
Sensors: The sensor, with built-in valve stem, is inserted from the inside of the wheel, through a hole in the rim. It is retained by a nut (4 n.m, 35 lb. In.) and is sealed by a grommet. The sensor is powered by a lithium battery with a design life of 10 years. Each sensor is coded differently. This permits the receiver to determine exactly which tire is over or under inflated.
Operation: The sensors operate only above 20 mph (32 kph) and transmit once per hour when parked, to preserve battery power. If the pressure in a tire rises or falls outside the calibration limits, the condition is displayed by the DIC. The low limit is 24 psi (168 kPa) and the upper limit is 39 psi (272 kPa).
Service: The sensors are lightweight, only about an ounce (28 g), and this small weight is easily accounted for during normal tire balancing. The sensors are mounted within the well of the rim. It’s important to be careful when using a tire mounting machine. The sensor could be damaged in two ways: either by direct contact with the machinery or by the bead of the tire as it is forced over the rim. The valve stem cap is made of aluminum and the valve core is nickel-plated to resist corrosion. The end of the stem serves as the sensor’s antenna.
Tip: Do not replace either the cap or the valve with standard parts. This will interfere with the sensor’s ability to transmit. The TPM sensor is more precise than consumer-grade tire pressure gauges. It may be necessary to explain this if the customer routinely mis-inflates tires using a gas station gauge.
Receiver Programming: The receiver is programmed at the factory to recognize which sensor is at each wheel location. If tires are rotated or a sensor is replaced, the receiver must be reprogrammed, following SI procedures. If the receiver is not reprogrammed, the system will continue to report the correct pressures, but will assign them to the wrong locations on the vehicle.
Tip: There are two reprogramming methods. You must use the J-41760 Kent Moore magnet when a new sensor is installed. During tire rotation, you can use either the magnet or your Tech 2.
Magnet Method: You will have only one minute between horn chirps, and five minutes overall, to complete the procedure once you start. With ignition on, engine not running, press both lock and unlock buttons on the key fob. A horn chirp within 10 seconds indicates that the receiver is in programming mode. At each wheel, hold the J-41760 magnet over the valve stem until the horn chirps, to force the sensor to transmit its code. You MUST follow this order: LF, RF, RR, LR. The horn chirps twice to indicate completion. Scroll through the DIC readout to verify all four pressures are displayed.
Tech 2 Method: With the TPM reprogramming procedure on your Tech 2, you can command each sensor to its new location. As long as no new sensors are being installed, the magnet is not needed. Scroll through the DIC readout to verify all four pressures are displayed.
NOTE: If you are wanting your own special magnet give Fichtner Chevrolet a call at 406-628-4618 or email at parts@fichtnerchevrolet.com to check on current price and avail.

MAGNETIC SELECTIVE RIDE CONTROL

If your 2003 corvette has magnetic selective ride control (RPO F55) and seems to have a stiff ride check this. This is new vehicle prep bulletin. When the ignition is turned off, the dampers offer very little damping. So, plastic stuffers are inserted in the dampers for shipping from the factory. The stuffers are to be removed during new vehicle prep. Failure to do so will result in customer dissatisfaction with the vehicle’s ride quality. See bulletin 02-03-11-002 for complete details. You can recognize the presence of Ride Control three ways: Ride control button on console, Corrugated dust boots on dampers, Yellow tabs protruding from dust boots. To remove the stuffers, lift the vehicle to allow the wheels to hang free. Reach from below, behind the tire. Compress the dust boot and pull the yellow tab to remove the stuffer. There is a stuffer on each damper, front and rear. After removing the stuffer, be sure to pull the dust boot down to cover the upper end of the damper tube.

D: SPECIALTY PARTS AND PART TECHNICAL INFORMATION

GM in their great wisdom is doing another design change on the (AQ9) sport style seat covers. Up till now you could get the outer bolster and insert as separate pieces for the seat back covers. Someone determined the zipper system was not satisfactory and has redesigned it, and you now get the bolster and insert together as a matched set. They also said the new zipper is not compatible with the old zipper system. Basicly this eliminates you from being able to two tone your seats as we could before. I had a polite but firm temper tantrum with them about this, but they are also drasticly changing the prices. Some are doubling, some by 50 %. It is not consistent, and pricing is looking into the matter. Until this matter is resolved pricing, availability and application will probably change on a daily basis. CALL if you are wanting to make a seat cover change, so we can get the latest info and prices for you. 406-628-4121

COLOR MATCH ON CARGO COVER LIDS

Some people have commented that the rear cargo covers are not an exact match to their
Interior color; mostly on the black. I have visited with GM and they say it is due mostly to slight variances in dye lots, and is not a defect in any way. They also said the direction of the carpet nap will make the color change slightly.

AC DELCO UPF 44 OIL FILTERS

UltraGuard Oil Filters
The ACDelco UPF44 filter has a 98% efficiency rating at 8-10 microns. They trap particles up to four times smaller than particles trapped by conventional filters. They reduce engine wear by up to 74%. Ultraguard filters use 100% synthetic wire-backed gold media to ensure superior filtering and the gasket is Teflon coated. For more information please visit the ACDelco website at: http://www.acdelco.com

2002 & NEWER LS6 AIR INTAKE COVER

The 2002 Air Cleaner Top Housing Cover is a SIMPLE snap-in replacement of the cover on any C5!! Our customers have reported a HUGE difference in throttle response in all gears and at all speeds. It obviously works because it is standard on the 2002 Z06! This is the least expensive and most effective modification you can make.
Here are some dyno results: Allan Grossman (allanlaw on the Forum)
HP increase from 294 to 308 TQ increase from 307 to 323
THANKS FOR THE INPUT ALLAN!!
Go here for a photo: http://www.c5registry.com/2k2z06/photos/07l.jpg

WE ALSO HAVE SERVICE AND OWNERS MANUALS AVAILABLE FOR MOST GM CARS AND TRUCKS. Call or email for prices and availability.

*GM Licensed Corsa Exhaust Systems

We have just signed an agreement to stock and sell GM Licensed Corsa Exhaust Systems. I am pleased to be able to provide special pricing to CorvetteForum members. To place an order please call me at 406-628- 4121 or email us at corvetteparts@hotmail.com
NOTE: Corsa has added a $75.00 surcharge for drop shipping. This is in addition to the
regular freight charge. We will check all avenues to ship to you the least expensive way
we have available. In most cases we will have the system shipped to us and then forward
it on to you.

CALL US FOR SPECIAL PRICES ON CORSA EXHAUST SYSTEMS
WE CAN MATCH OR BEAT MOST PRICES!

C5 Corvettes:
Touring Classic Exhaust System $940 Retail
Touring Pro Exhaust System $1040 Retail
Touring GTR Exhaust System $1150 Retail
Indy Classic Exhaust System $940 Retail
Indy Pro Exhaust System $1040 Retail
Indy GTR Exhaust System $1150 Retail
We also have the Corsa Tips available. Email or call for pricing and availability.
CORSA TITANIUM EXHAUST IS AVAILABLE IN LIMITED SUPPLY!!
Call Bob or Tom for special pricing and availability. 406-628-4121
We have Corsa systems available for C4 applications as well as the new Silverado/Sierra
Tahoe/Suburbans and Avalanche vehicles. Call us for special pricing.

Prices do not include the S/H. Remember, we don’t charge an arm and a leg for the S/H.
*Remember that we sell all Genuine GM parts to CorvetteForum members at dealer wholesale prices without any sales tax. Further, we ship daily with UPS without EXHORBIDANT shipping and handling charges!
Call Bob or Tom today at 406-628-4121 to purchase these items!!

Parts Details:

Brakes

C5 Corvette Section:

Questions on Delco Durastop brakes and rotors?
*AC Delco Durastop Performance now has a direct toll free number for technical advice and assistance. The number is 1-888-701-6169

C5 Durastop Performance Drilled/Slotted Rotors
ACDelco DuraStop are now offering drilled and slotted Performance Rotors for C5 Corvettes! The DuraStop Performance rotors are drilled and slotted to dissipate heat much quicker with an increase in overall performance. All rotors have been D3EA certified to assure quality as well.
They are available NOW for immediate shipment.

$138.00 per rotor – Forum member price

Z06 Calipers
Front - $117.33 per side - Forum member price
Rear - $85.41 per side - Forum member price

Z06 2002-Newer Front Brake Pads – Forum member price $128.63

C5 Original Equipment Brake Pads
Front Set(4 pads) - Forum member price $77.00
Rear Set(4 pads) - Forum member price $61.04

C5 GM Durastop Brake Pads
Front Set(4 pads) Forum member price $70.86
Rear Set(4 pads) Forum member price $58.49

C5 Corvette Racing HD Front Brake Pads
$114.75 per set(4 pads) Forum member price

C5 Corvette ACDelco Durastop Ceramic Wave II Brake Pads

Noise Suppression: 100% shimmed, 100% slotted, 100% chamfered. AC Delco Durastop provides ultra-quiet braking due to the absence of iron and steel fibers in the friction formulation.
Durability: Ceramic friction lasts longer than other non-ceramic friction.
Low Dusting: AC Delco Durastop Ceramic Friction was specially developed to reduce the ANNOYING dust that is typically found in ordinary friction formulations.
Warranty: AC Delco Durastop Ceramic Friction will provide a limited lifetime warranty.
These are available for many different GM models in addition to Corvettes!!
GM Durastop Ceramic Wave II Brake Pads
Front Set(4 pads) Forum member price $100.93
Rear Set(4 pads) Forum member price $70.78

Leather Care:

Lexol preserves, strengthens and beautifies leather! It protects old and new leather from cracking and premature aging. It is made with the finest tanning oils which bond to the leather fibers, nourishing the leather and leaving NO greasy residue. Use Lexol regularly to keep your leather looking and performing its best.
This product is the only product endorsed by those who sell and distribute virgin leather. We have made arrangements to buy this product from a wholesaler and are passing the discounts on to all Forum members.
Lexol premium applicator sponges are specifically designed for use with the Lexol leather treatment. They are composed of non-abrasive terry cloth wrapped over a sponge. They clean easily and are machine washable. Each package includes two applicators.
Lexol Leather Cleaner. Corvette Forum member price $5.95.
Lexol Leather Treatment. Corvette Forum member price $5.95.
Lexol Applicators. Corvette Forum member price for package of 2 $5.00

Paint Repair:

We now stock the GM Vehicle Care Paint Chip Repair Kit. The kit includes a spot sanding pen, clear coat paint, ultra fine polish, paint applicators, mico-fine polishing sandpaper, and a special flexible sanding block. Everything you need except for the color paint! Corvette Forum member price $8.68 per Repair Kit.
We also carry the touch-up paint to match your car.
Corvette Forum member price $6.95 per tube and $8.95 per spray can.
Genuine GM/AC Delco Parts for C1, C2, C3 and C4 Corvettes!!
We are pleased to announce that we are now offering Genuine GM/AC Delco parts for all years of Corvettes as available from GM at dealer wholesale pricing. Our parts department is ready to accept your orders today!

C5 Remote 12 Disc CD Changer & Harness

We are pleased to announce that the Changers and Installation Kits including all wiring harnesses are now available. This package can be installed in any C5 having the Bose in-dash CD or Cassette.
12 Disc CD Changer $419.16 Forum Member Price
Installation Kit $94.74 Forum Member Price
12 Disc CD Caddy $49.39 Forum Member Price
12 Disc Changer wire harness only $47.92 Forum Member Price

European Lamps

We have sold hundreds of sets of European Headlamps, Taillamps, Rear Side Marker Lamps, and Front Marker/Turn Signal Lamps.
European Headlamps $154.70/pair Forum member price
European Taillamps-Red/Clear $38.08/pair Forum member price
European Taillamps – Red/Amber $105.04/pair Forum member price
European Rear Side Marker Lamps $16.68/pair Forum member price
European Front Side Marker/Turn Signal Lamps $134.98/pair Forum member price
We also have the connectors for the European Headlamps in stock!

Interior Trim

We have added a complete list of seat trim, door panels, and lower dash components to change your C5 interior to either the Torch Red, Oak, or Light Gray Custom Leather Trim offered on Coupes and Convertibles or to the Modified Torch Red Z06 Leather Trim.
Check the complete parts listing below for the items and pricing.

Removable Top Rear Storage Compartment Retainers

We have these available for 1997-2004 Coupes. This is the retainer that has the rubber tip that holds the removable top securely in place while stored in the back of the coupe. Unfortunately the tip is not serviced separately. GM only offers the entire retainer assembly.

C5 Lug Nut Covers & Locking Lug Nuts

Black Lug Nut Covers. $1.39 per cover Forum member price
Gray Lug Nut Covers. $2.71 per cover Forum member price
Locking Lug Nut Set. $22.95 Forum member price
2002 Mid Year Stainless Capped Lug Nuts. $2.94 per nut Forum member price
2002 Mid Year Locking Lug Nut Set. $22.95 Forum member price.

Z06 Items:

Z06 LS6 Manifold

Package Includes: LS6 Manifold, CrossOver Pipe, CrossOver Pipe Plugs
Forum Member Price $509.82

Z06 Clutch/Flywheel Package

The pressure plate/disc and flywheel are $399.46
LS6 clutch slave cylinder assy $101.55
LS6 clutch master cylinder assy $101.55

Z06 Grilles

Easy to mount with two-sided tape, velcro or by drilling the front fascia and securing with fasteners. You may use the grilles with the fog lamps and either with or without the stock filler panel. For functionality you should remove the stock filler panel thus allowing more air into the engine compartment.
$51.52 Forum member price per side

Z06 Fuel Rail Covers

Simple to install direct snap on replacements for the stock 1999-2002 LS1 fuel rail covers. The Forum member price is $49.39 ea.

Z06 Aluminum Wheels 2001 Style

Retro fit your Coupe/Convertible/Hardtop or buy an extra set for your Z06!
Note: We will need a Z06 serial # to order these from GM as they are under order control.
2002 Style Z06 Wheels now available..call us for pricing

Rear Compartment Cover and Retainers for the 2001/2002 Z06

This is the cover that is standard on the Coupe & Convertible. Black carpeted cover with the retainers and latches included: Forum Member Price $81.02 for the cover and $2.97 per latch. The side covers are also available at 79.28 ea and the latch’s are 2.97 ea.

Transparent Roof Panel for 1997-2003 Coupes

This is a complete assembly including latches, retainers, side weatherstrips, and blow out clips: Forum Member Price $1033.60

Primed Roof Panel for 1997-2003 Coupes- same as above

Wheels:

High Polished Forged & Painted Cast Aluminum Wheels:
We are once again taking orders for and shipping High Polished FORGED Aluminum Wheels! Check price list for latest pricing.
The 2nd design Painted Cast Aluminum Wheel is now available for immediate shipment should anyone desire to update their 1997-1999 Corvette. This is the wheel with slightly larger spokes, painted in silver that was introduced midway thru 2000.
Check price list for latest pricing.

Passenger Side Air Bag Cutoff Switch

Many of you have requested information on the air bag cutoff switches for C5’s. We are offering the kits at special pricing for Forum members!
Here are the details:
1) This is a complete kit including instructions.
2) The kit has a part number based on year, body style and interior color.
3) Pricing: $110.50 plus S&H to Forum members.
4) Availability: Orders are arriving daily.
5) Ordering instructions: Call Bob at 406-628-4121. He will need your complete VIN, shipping instructions and credit card number.
We also have the center console bezel with the airbag on/off indicator now available!
Note: We have air bag cut off packages available for many different GM vehicles. These are completely legal and offered by GM as a retrofit kit.
Call us at 406-628-4618 or email at corvetteparts@hotmail.com for complete information
Please supply the vehicle vin # so we can get you the correct information.

Suspension Packages:

Z51 Suspension upgrade Package (GM Accessory)
NOTE THAT THE LINKS INCLUDED IN THE PACKAGE ARE THE SAME AS THE 2002 AND NEWER Z06 ALUMINUM LINKS.
Note that you do not need to replace the front shaft insulator brackets per the parts catalog from GM. This package is assembled with the individual components that make up the changes in the factory installed 2000-2002 Z51 suspension package. This package has been installed by many forum members on 1997-2002 C5’s having the standard suspension, F45 suspension or pre-2000 Z51 suspension with fantastic results. You will not sacrifice any ride quality but will dramatically improve the handling and feel of your C5.
FOR MORE DETAIL ON THE Z51 PACKAGE AND IT’S INSTALLATION PROCEDURE, PLEASE VISIT CHAZ’S PAGE (HE’S A FORUM MEMBER): http://www.chazcone.com/corvette/z51/
NOTE: THE REAR BRACKETS ARE NO LONGER REQUIRED AND WE NOW
INCLUDE (4) ALUMINUM LINKS.

Z06 Suspension upgrade Package

NOTE THIS IS THE 2002 & NEWER STYLE Z06 BAR PACKAGE

The package includes front and rear bars, front and rear bushings, and front and rear aluminum links. Installation info is the same as the above Z51 kit.


NEW PARTS ORDER LINK, CLICK HERE http://www.corvetteforum.net/c5/kenf...rtspage1.shtml

E: SHIPPING AND WARRANTY INFORMATION

SHIPPING POLICY:
Shipping and Insurance are additional on each order unless otherwise specified. Ground shipping is standard with air available upon request with an additional charge. In certain situations a drop ship direct from GM or the manufacturer is used, especially on large items.
Shipping and handling-std ground
Up to $50.00…………………………..…$ 7.99
$50.01 to $100.00…………………….$ 11.99
$100.01 to $200.00………………….$ 14.99
$200.01 to $400.00………………….$ 21.99
$400.01 to $500.00………………….$ 25.99
$500.01 to $600.00………………….$ 29.99
$600.01 to $800.00…………………$ 36.99
$800.01 to $1000.00………………………….. $ 39.99
$1000.01 to $1500.00…………….$49.99
$1500.01 and up……..$59.99

For extra heavy parts like clutch’s, rotors, exhaust systems etc. call for shipping quote.

Some parts are oversize or extra heavy call 406-628-4618 or email at Parts@FichtnerChevrolet.com for shipping charges on these items.
RUSH AND AIR SHIPPMENTS ARE ALSO AVAILABLE, CALL OR EMAIL FOR PRICES
Wheels will also have a $ 5.00 per wheel packaging charge

FICHTNER CHEVROLET TERMS AND CONDITIONS OF SALE
Prior authorization must be given before any return may be made. All parts must be in the original, un-opened, un-damaged container or box. A copy of the original invoice must accompany the returned goods. Shipping costs will be the responsibility of the purchaser and a 20% restocking fee may apply. Electrical parts are non returnable, and no returns will be accepted after 30 days.
Fichtner Chevrolet reserves the right to change pricing at any time for any reason, or refuse to sell a part for any reason.


WARRANTIES:
Any warranties on the products sold are those made by the manufacturer. Fichtner Chevrolet expressly disclaims all warranties, either express or implied. The purchaser is responsible for determining the suitability and acceptance of any and all products purchased or installed. This includes OE replacement parts as well as modifications and upgrades.
Thanks for reading this section of this weeks’ news!





:chevy :flag

Dr. Dan

Bob,
Thanks so much for posting the TSBs again. For a while there, I understand that GM had a problem with that, but it lets us Vette owners know that the small problems that occur isn't just in our head and other owners are having the same problem. It also shows GM's willingness to acknowledge the problem and keep their cars in high regard with their owners :thumbs:

Dan

CorvettePartsBob

Your Welcome!

I have had some ask why I keep the older bulletins in my newsletter. I have found with the constant influx of new vette owners coming on the forum and are in need of the bulletin information. I'm glas also the GM is not restricting us putting the bulletin info out.

Bob :chevy :flag

bizaro

I searched for ten minutes for the "WE NOW HAVE A SPECIAL C4 SECTION" and could not find it. Either I'm a complete air head, which does happen depending on how much "CABO WABO" I have consumed, or your site needs a bit of work. :crazy: Could be more user friendly. Looking to spend some cash and couldn't. :cheers: :seeya

CorvettePartsBob

The C4 section comes up as part B of my newsletter, as it is too large for one post. It must have dropped off since no hits. I will be posting another letter tomorrow! Otherwise give me a call at 406-628-4618 or email me at parts@fichtnerchevrolet.com

Bob :chevy :flag