Battery compartment question
Thread Starter
Intermediate
Joined: Jul 1999
Posts: 36
Likes: 0
From: Auburn MI
Battery compartment question
All batteries, especially those used in the 76 era, had vents in the cell caps to let the gases out as they charged. So where do these gases go after they leave the battery. They go into the battery compartment and that compartment is sealed. It's the only compartment of the 3 that has a gasket around the lid. Is this a good design? I noticed boats and RVs make special provision to vent the battery compartment. :rolleyes:
Melting Slicks
Joined: Aug 2000
Posts: 2,310
Likes: 1
Re: Battery compartment question (fritz76)
I believe there is a hole in the center "floor" of the batter compartment.
I'm not sure if the gases coming out of a battery are heavier than air, if there's a vacuum effect when you're driving, or what; but maybe that's how it's vented.
I'm not sure if the gases coming out of a battery are heavier than air, if there's a vacuum effect when you're driving, or what; but maybe that's how it's vented.
Team Owner
Joined: Sep 2000
Posts: 65,981
Likes: 15
Re: Battery compartment question (fritz76)
The Jag XJS has the battery in the trunk. A tube connected to the battery vents the battery fumes to the outside. I have read that without that tube, the trunk metal corrodes quickly. I believe the hole in the bottom of the Corvette battery compartment should be opened.
Drifting
Joined: Nov 2000
Posts: 1,390
Likes: 39
From: North Brunswick NJ
Re: Battery compartment question (fritz76)
I know that batteries thru 74 [not sure about later models] had special caps that had vent tubes attached to the battery caps. These vent tubes vented through the battery compartment floor. These caps are still available through some of the battery restoration companies.
Ed
[Modified by ED DINAPOLI, 8:50 AM 1/13/2003]
Ed
[Modified by ED DINAPOLI, 8:50 AM 1/13/2003]
Melting Slicks
Joined: Aug 2000
Posts: 2,310
Likes: 1
Re: Battery compartment question (fritz76)
"In any event my floor hole has a plug in it. "
Check that "plug" from the underside.
It's been a while since I've looked at it, but I thought it looked like it had openings in it.
Check that "plug" from the underside.
It's been a while since I've looked at it, but I thought it looked like it had openings in it.
Drifting
Joined: Nov 2000
Posts: 1,390
Likes: 39
From: North Brunswick NJ
Re: Battery compartment question (Marks69BB)
I dont believe the drain hole was for venting gases. It was for drainage of liquid. If you notice the floor is tapered toward this drain hole. The vented caps and the vent tubes were for gas venting.
Ed
Ed
Corvette Stories
The Best of Corvette for Corvette Enthusiasts
Top 10 Most Expensive Corvettes Ever Sold on Bring A Trailer
Brett Foote
10 Things Every Corvette Owner Needs (2026 Edition)
Michael S. Palmer
8 Most "Only Corvette Owners Understand" Quirks and Problems
Pouria Savadkouei
10 Reasons the C6 Z06 is Still A Performance Benchmark After 20 Years
Joe Kucinski
How Much Horsepower Every Corvette Engine "LOST" in 1972
Joe Kucinski
Top 10 DOs and DON'Ts for Protecting Your Convertible Top!
Michael S. Palmer
Top 10 Most Explosive Corvettes Ever Made: Power-to-Weight Ratio Ranked!
Joe Kucinski
150 hp to 1,250 hp: Every Corvette Generation Compared by the Specs That Matter
Joe Kucinski
8 Coolest Corvette Pace Cars (and Replicas) of All Time
Verdad Gallardo
Thread Starter
Intermediate
Joined: Jul 1999
Posts: 36
Likes: 0
From: Auburn MI
Re: Battery compartment question (ED DINAPOLI)
I double checked my drain plug and it has slits in it too. I agree with Ed that it's made for draining liquids. It was mentioned that special battery caps with a vent tube were used. Where does this vent tube go? There aren't any other holes in the compartment and it surely doesn't go out under the battery through the floor hole. I checked my assembly manual and there aren't any vent tubes shown.
The reason I started this question is because my battery clamps were corroding excessively. The corrosive gases trapped in the compartment are a major reason I'm sure. Also, too much of this gas trapped in there can give an explosive situation. I'm using a new, maintainance free battery but even those have very small holes for ventilation. Back in 76 they didn't have the maintainance free batteries so they had more of the hydrogen gas to deal with. Wonder if there were any reports of explosions in the battery area over the years?
The reason I started this question is because my battery clamps were corroding excessively. The corrosive gases trapped in the compartment are a major reason I'm sure. Also, too much of this gas trapped in there can give an explosive situation. I'm using a new, maintainance free battery but even those have very small holes for ventilation. Back in 76 they didn't have the maintainance free batteries so they had more of the hydrogen gas to deal with. Wonder if there were any reports of explosions in the battery area over the years?
Race Director
Joined: Apr 1999
Posts: 11,520
Likes: 13
From: CORVETTE 77 385 C.I. TEXAS
Re: Battery compartment question (fritz76)
C3 came w/ special low gassing bat.
77 had the maintainance free w/ side posts which are very good about maintaining very good connections even w/o a coating.
77 had the maintainance free w/ side posts which are very good about maintaining very good connections even w/o a coating.
Instructor
Joined: Jul 2000
Posts: 239
Likes: 5
From: Rochester NY
Re: Battery compartment question (fritz76)
fritz76,
My 76 came with a Delco maintanece free battery w/side posts. There is a drain hole in the center of the compartment under battery.
No special vent tube used.
Ulf
My 76 came with a Delco maintanece free battery w/side posts. There is a drain hole in the center of the compartment under battery.
No special vent tube used.
Ulf
