Issue with my headlights
Thread Starter
Instructor
Joined: Jan 2012
Posts: 198
Likes: 8
From: Albuquerque New Mexico
Issue with my headlights
On my 2000 Corvette FRC ive been having issues where the headlights dont pop up unless i open the hood and manually turn the ***** on the headlight motor a little, turn the lights off and back on then they will come up. I do not hear any grinding or anything like that.
The picture below is the **** i turn:
The picture below is the **** i turn:
Team Owner
Joined: Dec 1999
Posts: 174,312
Likes: 1,217
From: Here
Pilot of Beer Force 1
Tampa Regional Coordinator
CI 4-5-6-7-8 Veteran
Organizer St. Jude Fundraiser
I believe in the Beer Fairy
check your stops...you see one there in the picture (yellow thing) there are several others, if they are missing or worn the light travels down too far and then has a hard time popping up. If the stop is worn you can try flipping it over, if it is missing you need to source some new ones
Melting Slicks
Joined: Jan 2009
Posts: 3,275
Likes: 739
From: Miami FL
Have you checked the rubber bump stops? You might need to replace them.Also, there is a TSB, that calls for shimming the driver's side motor.
There are 4 rubber bump stops per headlight assembly: 2 for "Close" and 2 for "Open". Check the following pictures to see where they are located.
CLOSE
OPEN
Last edited by GCG; Dec 16, 2017 at 09:25 AM.
Thread Starter
Instructor
Joined: Jan 2012
Posts: 198
Likes: 8
From: Albuquerque New Mexico
Thank you!
So i tried this. i turned all of them over and still having the same issue. It is usually the passenger side headlight that i have been having more issues with. I do have HIDs on the car and instead of the resistor i installed the relay kit.
I started having issues with the right headlight after installing the supercharger and i wouldn't think that would have any effect on it at all but i thought i would let you all know this info.
So i tried this. i turned all of them over and still having the same issue. It is usually the passenger side headlight that i have been having more issues with. I do have HIDs on the car and instead of the resistor i installed the relay kit.
I started having issues with the right headlight after installing the supercharger and i wouldn't think that would have any effect on it at all but i thought i would let you all know this info.
Thread Starter
Instructor
Joined: Jan 2012
Posts: 198
Likes: 8
From: Albuquerque New Mexico
i did flip them all over but i am going to order a new set of 8 and see if that will help. tired of my lights not working. its making me want to drive the cadi a lot more then the vette and thats not good lol
